自動熒光定硫儀

波長色散X射線硫含量儀

FX-700

適用于柴油/汽油超低硫含量測定

Model FX-700 determines total sulfur in ultra low sulfur (ULS) fuels using wavelength dispersive X-ray fluorescence (WDXRF) method, which is a quick, easy and economical technique described in ISO20884 and ASTM D2622.

FX-700 是按“波長色散X射線熒光光譜法（WDXRF） ”測定超低硫含量(ULS)的測試儀器。使用簡單，測試快速，結果準確，適用于標準 ISO20884 ， ASTM D2622。

SIMPLE OPERATION: Thanks to its dedicated design for ULS fuels, the operation has been simplified to the extreme. Just set a sample cell in the sample cell compartment and press the START key; no complicated parameter setting is required. As easy as a flash point test.

STAND-ALONE DESIGN: The stand-alone design does not require a PC, and the compact housing allows bench-top installation.桌面型儀器設計，可獨立操作，無須外接PC。

MINIMAM UTILITIES: Air-cooled small X-ray tube and gas filled proportional counter have been employed, and the only requirements are AC Power Source and Helium Gas.

使用簡單：儀器內置氣體密封型比例計數管，只要接上電源和氦氣（保護），就可以正常使用儀器。

OIL LEAK PROTECTION: Disposable cardboard sample cell is easy to assemble and thus cuts down oil leak. It also absorbs leaked oil, in case of leak, and let operator know the leak before analysis.

泄露保護：一次性紙制樣品杯裝配簡單，使用方便。油品泄漏時可以有效吸收，便于維護。

SAFE: Fail-safe design in conjunction with the small air-cooled X-ray tube assures operator’s safety.

BUILT-IN PRINTER: A built-in printer preserves the valuable test data. 內置打印機可打印出試驗結果。

TANAKAWDXRF Sulfur Analyzer, FX-700

TYPE:

Stand-alone Bench-Top type Wavelength Dispersive X-ray Fluorescence Analyzer for Sulfur in Oil

波長色散熒光X射線分析法，桌面型儀器

TEST STANDARDS: （適用標準）

ASTM D2622, ISO 20884, JIS K2541-7

SPECIMEN VOLUME: （樣品需求）

5mL

SAMPLE CUP:

Made of Paper, disposable type （專用一次性樣品杯）

MEASURING RANGE AND PRECISION: （測量范圍和精度）

0 to 990 ppm LOD: Approx. (typical)   0-999 ppm LOD, 重復性在 1.5 ppm 左右

TYPICAL MEASUREMENT TIME: （測試設定）

300 sec for S-k and 300 sec for Background

From 60 sec to 990 sec, selectable 時間（60-990秒），可自行設定

X-RAY TUBE: （x射線源功率）

Air Cooled Small X-ray Tube 小型空氣冷卻x射線源 (氦氣保護)

Power: 22 kV-1.8 mA (Approx. 40W) (約40w)

CRYSTAL:

Germanium (1.1.1)

DETECTOR: （傳感器）

Gas Filled Proportional Counter 氣體密封型比例計數管

OPTICAL PATH:

Filled with Helium gas (Purity: >99.9%) 需要氦氣保護（純度:99.9%）

MEASUREMENT MODES: （測量方式）

1.    BK ON mode: Measures S-k peak and then Background （有背景補償模式）

2.    BK OFF mode: Measures S-k peak only （無背景補償模式）

CALIBRATION CURVE: （矯正曲線）

8 Curves, Linear or Quadratic

DISPLAY: （顯示）

Test status, Sample Name, Raw Count Data, Sulfur Contents, etc are displayed on LCD.

LCD 顯示全試驗設定，試驗過程，試驗結果。

SAFETY SHUTDOWN:

When chassis around X-ray Tube is opened while X-ray source is ON, warning buzzer beeps and High Voltage for X-ray tube shuts off.

PRINTER: （打印）

Built-in, Thermal type （內置熱敏紙式打印機，紙寬）

DATA OUTPUT: （數據輸出）

RS-232C 1 channel （標準RS-232C接口，1）

DATA STORAGE （數據記錄）

Last 60 test data are stored in RAM 自動記錄后60次試驗結果

POWER REQUIREMENTS: （電源需求）

Single Phase 100, 120, 220, or 240VAC 0.3kW （單相交流電100, 120, 220, 或 240V，0.3kW）

GROUNDING: （接地電阻）

Resistance to earth: <100Ω （要求必須良好接地。接地電阻 <100Ω）

INSTALLATION SURROUNDING: （環境要求）

Room Temp.:10 to 30oC, diurnal variation < 10 oC Humidity: less than 80%

室溫10～30℃(一天內的溫差變化在10℃以下) / 濕度80‰ RH以下

DIMENSIONS AND WEIGHT: 尺寸/重量

600mmWx500mmDx520mmH, 66kg

ORDERING INFORMATION: STANDARD ACCESSORIES: （標準附件）

1.AC Cord 電源線	1 pc
2.Sample Cell Flange樣品杯底座	2 pcs
3.Sample Cell, Disposable, Cardboard (1000/box) 一次性樣品杯（1000/盒）	1盒
4.Jigs for Assembling Sample Cells樣品杯組裝工具	1
5.PEN Film (1.9µ, 125mm×250m) 測試膜	1
6.Printing Roll Paper打印紙	1
7.Peak Search Sample	1
8.Blower Brush 清潔刷	1
9.Lamp for Interlock 閉門指示燈	1
9.Lamp for X-Ray Warning X射線指示燈	1
10.Glass Tube Fuse 0.5A保險絲（0.5A）	1
11.Instruction manual使用手冊	1

OPTIONAL ACCESSORIES (START UP KIT): （推薦附件）

標準樣品，標定專用

1.Sulfur Standard 0.0 wt% level, 100ml

2.Sulfur Standard 100 ppm level, 100ml

3.Sulfur Standard 200 ppm level, 100ml

4.Sulfur Standard 500 ppm level, 100ml

SUGGESTED SPARES FOR 2 YEARS (2,000 Tests): （推薦附件，2年維護或2000次測試）

1.PEN Film (1.9µ, 125mm×250m) 測試膜	4卷
2.Sample Cell, Disposable, Cardboard (1000/box) 一次性樣品杯（1000/盒）	2盒
3.Printing Roll Paper (2rolls/pack) 打印紙（2卷/包）	10包

PACKING SIZE AND WEIGHT （包裝體積/重量）

FX-700 & Standard Accessories:（儀器本體+附件）

1-Carton Box, 77 x 82 x 113cm, Net:80/Gross:95/Vol:119kg

Optional Accessories and Suggested Spares for 2 years: （推薦附件+2年備件）

1-Carton Box, 66 x 63 x 74cm, Net:25/Gross:33/Vol:52kg